2005 Scion Tc Recalls

The defect

ON CERTAIN VEHICLES, THE SIDE IMPACT SEAT-BOLSTER AND CURTAIN SIDE AIRBAGS MAY INADVERTENTLY DEPLOY. THIS CONDITION CAN OCCUR IF THE DOOR FOR THAT SIDE OF THE VEHICLE IS CLOSED WITH A HIGH RATE OF FORCE WHILE THE VEHICLE'S IGNITION IS IN THE "ON" POSITION OR WITHIN 90 SECONDS OF TURNING THE IGNITION KEY FROM THE "ON" POSITION TO THE "OFF" POSITION.

The risk

IF THE SIDE IMPACT SEAT-BOLSTER AND CURTAIN SIDE AIRBAGS INADVERTENTLY DEPLOY, THEY COULD CAUSE PERSONAL INJURY IF AN OCCUPANT IS SEATED ON THE SAME SIDE OF THE VEHICLE AS THE DOOR THAT IS CLOSED WITH A HIGH RATE OF FORCE. UNTIL THE REPAIR HAS BEEN PERFORMED, IT IS RECOMMENDED THAT A MINIMAL FORCE/SPEED BE USED TO CLOSE THE DRIVER AND PASSENGER DOORS OR CLOSING THE DOORS AFTER 90 SECONDS HAVE ELAPSED FROM TURNING THE IGNITION KEY FROM THE "ON" TO THE "OFF" POSITION.

The fix

DEALERS WILL REPLACE THE TWO SIDE IMPACT AIRBAG SENSORS AND INSTALL A URETHANE PAD IN THE FRONT DOORS, IF NECESSARY, FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-866-548-1851.

The defect

ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH A GLASS WIND DEFLECTOR, THE DEFLECTOR, IF IMPACTED BY A PROJECTILE, SUCH AS ROAD DEBRIS, WHILE DRIVING WITH THE WIND DEFLECTOR IN THE UPWARD-TILTED POSITION AT HIGHWAYS SPEEDS, MAY SHATTER AND SEPARATE FROM THE FRAME.

The risk

PIECES OF THE WIND DEFLECTOR GLASS MAY SEPARATE FROM THE FRAME AND FALL UPON THE VEHICLE OCCUPANTS CAUSING DRIVER DISTRACTION AND/OR INJURY.

The fix

DEALERS WILL INSTALL A PROTECTIVE LAMINATE TO THE WIND DEFLECTOR TO PREVENT PIECES OF GLASS FROM SEPARATING FROM THE WIND DEFLECTOR FRAME. THE RECALL BEGAN OCTOBER 27, 2005. OWNERS MAY CONTACT TOYOTA AT 1-866-707-2466.

The defect

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

The risk

THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

The fix

DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

Reported March 2, 2010 by GULF STATES TOYOTA, INC.

The defect

ON CERTAIN VEHICLES, DUE TO IMPROPER ASSEMBLY OF THE AIR BAG INFLATOR, WHICH IS USED IN THE SIDE AIR BAG, THE CURTAIN SHIELD AIR BAG, AND THE KNEE AIR BAG ASSEMBLY, SOME INFLATORS WERE PRODUCED WITH AN INSUFFICIENT AMOUNT OF THE HEATING AGENTS NECESSARY FOR PROPER AIR BAG DEPLOYMENT. IN THIS CONDITION, THE EXPANSION FORCE OF THE GAS MAY BE INSUFFICIENT TO PROPERLY INFLATE THE AIR BAG WHEN THE SRS SYSTEM IS ACTIVATED DURING A CRASH.

The risk

THIS MAY INCREASE THE RISK OF INJURY TO THE OCCUPANT IN THE INVOLVED SEATING POSITION IN THE EVENT OF A CRASH.

The fix

DEALERS WILL REPLACE THE SPECIFIC SRS AIR BAG. THE RECALL BEGAN ON APRIL 6, 2006. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371, SCION AT 1-866-548-1851, OR LEXUS AT 1-800-255-3987.

Reported March 4, 2006 by TOYOTA MOTOR NORTH AMERICA, INC.