2007 Pontiac Torrent Recalls

The defect

General Motors (GM) is recalling certain model year 2007 Chevrolet Equinox and Pontiac Torrent vehicles originally sold or currently registered in Arizona, California, Nevada, and Texas; model year 2007 Chevrolet Cobalt, Pontiac G5, and Saturn ION vehicles originally sold, or currently registered in, Arizona, California, Florida, Nevada, or Texas; model year 2008 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arizona; and model year 2009 Chevrolet Cobalt and Pontiac G5 vehicles originally sold, or currently registered in, Arkansas, Arizona, California, Nevada, Oklahoma, or Texas. Some of these vehicles have a condition in which the plastic supply or return port on the fuel pump module may crack, which could cause a fuel leak.

The risk

Fuel leakage in the presence of an ignition source may result in a fire.

The fix

GM will notify owners, and dealers will replace the fuel pump module, free of charge. Notification to owners began on on November 21, 2012. Owners were instructed to not bring their vehicles in for repair until January 2013. Owners may contact General Motors at 1-800-521-7300.

The defect

CERTAIN VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 212, "WINDSHIELD MOUNTING." AN INCORRECT PRIMER MAY HAVE BEEN USED WHEN INSTALLING THE WINDSHIELD. THE SAME PRIMER MAY HAVE ALSO BEEN APPLIED TO THE LIFTGATE GLASS AND THE SIDE STATIONARY GLASS.

The risk

IN THE EVENT OF A CRASH, THE WINDSHIELD MAY NOT BE RETAINED TO THE EXTENT REQUIRED BY THE STANDARD, INCREASING THE RISK OF PERSONAL INJURIES TO THE VEHICLE OCCUPANTS.

The fix

DEALERS WILL REPLACE THE WINDSHIELD, THE LIFTGATE GLASS, AND THE SIDE STATIONARY GLASS. THE RECALL BEGAN ON JUNE 14, 2007. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.

The defect

CERTAIN PASSENGER VEHICLES NOT EQUIPPED WITH OPTIONAL ROOF RAIL AIRBAGS OR OPTIONAL SUNROOF FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201,"OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING NHTSA IMPACT TESTS, THE INTERIOR OCCUPANT PROTECTION TEST POINTS EXCEEDED THE STANDARD REQUIREMENTS.

The risk

THE RESULTS OF THIS TEST INDICATED A POSSIBILITY OF AN INCREASED RISK OF HEAD INJURY IN A CRASH.

The fix

DEALERS WILL INSTALL AN ENERGY ABSORBING FOAM PIECE TO EACH OF THE A-PILLAR TRIM ASSEMBLIES FREE OF CHARGE. THE RECALL BEGAN ON MAY 8, 2008. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.

Reported July 11, 2007 by GENERAL MOTORS CORP.

The defect

CERTAIN SPORT UTILITY VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." IN THESE VEHICLES, THE RIGHT FRONT PASSENGER SEAT IS BUILT WITH A PASSENGER SENSING SYSTEM. WHEN TESTED WITH A REPRESENTATIVE UNRESTRAINED SMALL ADULT, THE SYSTEM IS REQUIRED TO TURN THE RIGHT FRONT PASSENGER'S FRONTAL AIRBAG ON. AN ERROR IN THE SEAT SENSOR CALIBRATION CAN CAUSE IT TO FAIL THIS TEST. IN ADDITION, THIS CONDITION CAN PREVENT THE AIRBAG FROM TURNING OFF WHEN THE SEAT IS OCCUPIED BY A SMALL CHILD.

The risk

WHENEVER THE FRONT PASSENGER SEAT IS OCCUPIED, THE DRIVER SHOULD ALWAYS CHECK THE AIRBAG INDICATOR TO SEE IF THE AIRBAG IS ON OR OFF. IF IT IS NOT CORRECT FOR THE SITUATION, THE PASSENGER SHOULD BE MOVED TO A DIFFERENT SEAT. THIS CAN INCREASE THE RISK OF INJURY TO A SEAT OCCUPANT DURING CERTAIN CRASH CONDITIONS.

The fix

DEALERS WILL REPROGRAM THE SEAT'S ELECTRONIC CONTROL UNIT. THE MANUFACTURER HAS NOT YET PROVIDED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR PONTIAC AT 1-800-620-7668.

Reported July 8, 2007 by GENERAL MOTORS CORP.